Vehicle history & safety reports built from official U.S. records
For DealersDealer Sign InSign InCreate Account
Carchieve
← All vehicles

2005 Toyota Prius: Recalls, Complaints & Safety Ratings

6Safety recalls
1,051Owner complaints
—NHTSA overall
Quick answer

The 2005 Toyota Prius has 6 NHTSA safety recall campaigns and 1,051 owner complaints on file. Check a specific VIN to confirm whether recalls apply, whether repairs were completed, and what to verify before you buy.

2005 Toyota Prius safety record graphic showing 6 recalls, 1,051 owner complaints.
Check the exact car

Run a full report for this Prius

2005 Toyota Prius pages show model-level safety data. A Carchieve VIN report checks the exact car before you buy.

Safety record reviewed June 2026 · sourced from NHTSA

The 2005 Toyota Prius has 6 safety recall campaigns and 1,051 owner complaints on file with the National Highway Traffic Safety Administration. Below is the public model-level safety record. To see whether a specific Prius had applicable recalls repaired and what its decoded VIN says, run that car's VIN.

Safety recalls

1

STEERING

Campaign 12V537000 · 14/11/2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

RiskOver time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
RemedyToyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
2

ENGINE AND ENGINE COOLING

Campaign 12V536000 · 14/11/2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

RiskThe corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
RemedyToyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
3

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Campaign 09V388000 · 05/10/2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

RiskA STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
RemedyTOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
4

AIR BAGS

Campaign 06V096000 · 03/04/2006

ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.

RiskTHIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
RemedyDEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
5

EQUIPMENT:OTHER:LABELS

Campaign 10V036000 · 03/02/2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

RiskA DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
RemedyDEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
6

STEERING:ELECTRIC POWER ASSIST SYSTEM

Campaign 06V188000 · 31/05/2006

THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.

RiskTHIS COULD RESULT IN A LOSS OF STEERING CONTROL OF THE VEHICLE.
RemedyTOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

What owners complain about

The systems 2005 Toyota Prius owners report most often to federal regulators:

Exterior Lighting346
Service Brakes281
Electrical System178
Hydraulic128
Vehicle Speed Control109
Electric68

Frequently asked questions

Does the 2005 Toyota Prius have any recalls?

Yes. The 2005 Toyota Prius has 6 NHTSA recall campaigns associated with this model year. Recall repairs are free at a franchised dealer when the exact VIN is affected. Check your specific VIN to confirm applicability and completion.

What problems do 2005 Toyota Prius owners report?

Owners have filed 1,051 complaints with the NHTSA for the 2005 Toyota Prius, most often about the exterior lighting, service brakes, electrical system.

How do I check a specific Prius's history?

Enter the 17-character VIN into Carchieve. You get the recalls, owner complaints and crash ratings shown here for that exact vehicle, plus full decoded specifications and a guided title and odometer check.

Check a specific 2005 Toyota Prius

This page covers the model. For one exact car, run its 17-character VIN to confirm recalls, decoded specifications and buyer checks.

Get Full Report

Other model years

2024 Toyota Prius2023 Toyota Prius2022 Toyota Prius2021 Toyota Prius2020 Toyota Prius2019 Toyota Prius2018 Toyota Prius2017 Toyota Prius